Aqua N Water Solution
Aqua N Water Solution
Gujarat , Ahmedabad , India, Gandhinagar, Gujarat
GST No. 24BSQPP2600C1Z2
TrustSEAL Verified
Call 0804861299262% Response Rate
SEND EMAIL

Ultra Filtration Plant

Our product range includes a wide range of uf ro plant, commercial reverse osmosis plant, cooling tower blow down water filtration plant and whey protein uf filtration plant.

Uf Ro Plant

Uf Ro Plant
  • Uf Ro Plant
  • Uf Ro Plant
Get Best Quote
Approx. Price: Rs 6.9 Lakh / PieceGet Latest Price

Product Details:

Minimum Order Quantity1 Piece
Usage/Applicationafter wast water treatment & Before Ro Plant
Filter TypeUF Membrane Filtration
Model Typeuf
Capacity60m3 day
BrandAqua N water solution
Filter Medium MaterialMicrofiber
Plant Applicationwast water filtration

01. Ultra filtration

An ultra filtration membrane is a membrane that effects separation on the principle of sieving. The membrane has pores that are in the nanometer size range, and will therefore prevent particles, colloids, microorganisms and dissolved solids that are larger in dimension than the pores in the membrane surface from passing. The membrane therefore acts as a physical, size-exclusion barrier, and it is for that reason that ultra filtration membranes produce such a high quality product.

Ultra filtration membranes are produced in either flat-sheet or tubular-type geometries. The membranes that were used in this study are referred to as capillary membranes. The membranes are narrow-bore tubes that have an outside diameter of 1.8 mm and a lumen (bore) diameter of 1.2 mm. The membranes are internally skinned, which means that the pre-treated feed water enters into the lumen from where it filters outwards under a pressure driving force. The trans-membrane pressure required to produce clean-filtered water is typically less than 2 kg/cm2, typically 1.2 kg/cm2

 

• Produces a MF/UF quality effluent suitable for reuse applications or as a high quality feed water source for Reverse Osmosis treatment. Indicative output quality of MF/UF systems include SS < 1 mg/L, turbidity < 5 NTU and up to 4 log removal of virus (depending on the membrane nominal pore size). In addition, MF/UF provides a barrier to certain chlorine resistant pathogens such as Cryptosporidium and Giardia.

 

• The resultant small footprint can be a feature used to address issues of visual amenity, noise and odour.

Scope of Supply

02. Ultra Filtration

 

§ Pre-filter

§ membrane Module

§ Electrical control panel

§ Electrical control valves (Product & Reject flow)

§ Rota meter

§ Pressure gauge

§ Mild steel PU painted frame

§ UPVC piping , hoses & quick coupling complete

§ Feed pump

§ Back flush pump

§ In-built EBF & CIP (Clean-in-Place) valve configuration

Request
Callback


Additional Information:

  • Production Capacity: 60 m3 day
  • Delivery Time: 30 day
  • Packaging Details: as per requirement
Yes! I am Interested

Commercial Reverse Osmosis Plant

Commercial Reverse Osmosis Plant
  • Commercial Reverse Osmosis Plant
  • Commercial Reverse Osmosis Plant
  • Commercial Reverse Osmosis Plant
Get Best Quote
Approx. Price: Rs 1.95 Lakh / PieceGet Latest Price

Product Details:

MaterialMS
Automation GradeAutomatic
Plant Area300 sq feet maximum
Installation/Civil WorkAvailable
Number of Membranes in RO1
ConditionNew
Max Water Recovery Rate60-65 %, 55-60 %
Number of Filtration Passes>5
Purification TypeRO
RO Capacity1000-2000 (Liter/hour)
Voltage220 V
Recovery rate50%-75%

Commercial Reverse Osmosis Plant send midea filter frp carbone midea filter FRP Microne filter frp 20/4 dia Hpp pump , Electric penal Ultraviolet system, online water testing miter
Request
Callback
Yes! I am Interested

Cooling Tower Blow Down Water Filtration Plant

Cooling Tower Blow Down Water Filtration Plant
  • Cooling Tower Blow Down Water Filtration Plant
Get Best Quote
Approx. Price: Rs 3.45 Lakh / PieceGet Latest Price

Product Details:

Minimum Order Quantity1 Piece
Usage/ApplicationCooling tower blowdown (CTBD) water treatment
Filter TypeRevers osmosis plant
Model TypeSoftener + RO
Capacity3m3hr
BrandAqua N water solution
Flow Rate>4000
Country of OriginMade in India

The make-up water Cooling tower blowdown water treatment presents several challenges due to the high salt concentrations and chemicals added in the cooling tower. Any water source has various levels of dissolved and suspended solids. Because the evaporative loss is water containing little to no solids, the water remaining in the cooling tower becomes concentrated. New  water needs to be added to maintain the balance. However by equalizing the mass balance of water in the system, the amounts of dissolved solids will increase.

This can result in many problems in the cooling tower such as corrosion, scaling, fouling and microbiological growth. All these problems have an effect on performance and maintenance. In order to protect the efficiency and life expectancy of components, part of the concentrated water needs to be discharged. The purged water is called blow-down or bleed-off.

Blowdown water properties depend on pretreatment for makeup water and on number of cycles of concentration. Besides minerals (high TSS, TDS, Hardness and Alkalinity parameters), the water might also contain algae, bacteria (eg. Legionella), or pathogens. There are often chemical additives put in the water to impede scaling, reduce pH, inhibit corrosion, and kill biological contaminants (biocides).


Benefits of blowdown water treatment include:

  • less maintenance,
  • lower fouling and corrosion,
  • reduction of chemicals used,
  • more stable water quality.



Request
Callback


Additional Information:

  • Production Capacity: 1 m3 hour / 100 m3 hour
Yes! I am Interested

Whey Protein UF Filtration Plant

Whey Protein UF Filtration Plant
  • Whey Protein UF Filtration Plant
  • Whey Protein UF Filtration Plant
Get Best Quote
Approx. Price: Rs 7.9 Lakh / PieceGet Latest Price

Product Details:

Minimum Order Quantity1 Piece
Usage/ApplicationDairy Product
Filter TypeUltra filtration
Type Of MachinesU F Filtration
Model TypeAuto
Capacity2m3 hr
BrandAqua N water solution
Filter Medium MaterialPVDF , PAN
Size8x5x10
Flow Rate500-1000

our filtration is is applied to either skim milk or whey to concentrate the dry matter to the required total solids (TS%). The
commercially available powders names are based on the protein type: milk protein (named casein) or whey protein. Their protein
content (percentage of protein in the dry matter) ranges from 34-80% (e.g. Whey Protein Concentrate WPC60 has 60% protein
in the dry matter or Milk Protein Concentrate MPC60has 60% protein in the dry matter).

High-protein products such as Whey Protein Isolate WPI90 (90% protein in the dry matter) may first undergo a microfiltration
(MF) treatment step to lower the fat content. our (UF) is then applied to the MF defatted whey protein permeate to
standardize and increase the protein content in the total solids.

To maximize the solid content, it is common to use diafiltration (dilution with water) in later stages to wash more small non-protein
components (i.e. lactose and ash) into the UF permeate. It is also common to increase the feed spacer size of the element to
maximize the solid content during the later stages of the UF system. Additionally, a tighter UF membrane is commonly used for the
concentration of products with 80% protein (or more) in the dry matter.

Our Plant is a 10,000 Daltons (Da) molecular weight cut-off polyethersulfone (PES) UF membrane developed for use in food
& dairy applications. This membrane is commonly used for whey protein and milk protein concentration applications. Combined
with our sanitary outer shell, these membranes are ideal for milk and whey protein concentration.



i hope this information is okay for you so please send us your requirement so we will discuss on this

i am waiting your replay
Request
Callback


Additional Information:

  • Production Capacity: 1000 to 50000 liter per hr
Yes! I am Interested
X

Product Videos

Watch More Videos

Explore More Product

View All Product


Reach Us
Nilesh Patel (Proprietor)
Aqua N Water Solution
G-404, SUKAN SKY CORP,NR CITY PULSE,KUDASAN, Unit 2 /223-224 Gopal charan industrial Estet , Rod no 7 , Gujarat , Ahmedabad , India, Gandhinagar - 382421, Gujarat, India


Call Us


Send E-mail